355 Loud Rattle from Clutch Area

If they did not charge you for "rebuilding the Voith damper" then the grease was not replaced.

 

No chance the Voith was overhauled Ian. I have done this job 4 times now and there aren’t many ‘techs’ who venture into the Voith especially in Australia. Just spoke recently with a Ferrari trained tech of 11 years has never opened one.

 

Also if it’s not leaking evidently does not mean a past leak hasn’t been rectified and then the old contaminated Voith put back into action. The last Voith I re did was part of a triple seal leak repair. I wasn’t going to do the Voith but upon opening it up for inspection the grease inside was badly contaminated with gear oil and stunk like it too. So was worth the extra effort to rectify.

 

any update on this?

 

This is a real hunt for you guys hope you find it I’m sure you will share too


Sent from my iPhone using FerrariChat

 

That's great to hear, Ian. I can't understand that sonic response to a bad fuel injector and 8 spark plugs.

Barry

 

Yep. Misfire, rough running can often cause noise in manual transmission or dual mass flywheel. Typically they go away if the clutch is depressed because that stops the rotating mass in the trans from interacting with the engine, but with a dual mass flywheel not so much.

Think of a marble in a box. You accelerate the box forward and the marble hits the back of the box and stay there. But if the box decelerates, the momentum of the marble causes it to roll forward and strike the front of the box. When the box accelerates again, the marble doesn't accelerate until it strikes the back of the box. Rattle. Same type of thing happens in a transmission or dual mass flywheel when the engine RPM is unstable.

 

Congrats man, that makes sense..misfire, engine is imbalanced sort of..leads to sounds